MATERIAL SAFETY DATA S=
HEET
_____________=
_________________________________________________________________________
1.
PRODUCT A=
ND
COMPANY IDENTIFICATION
Synonyms:=
Solvent-Based Mastic
_________________________________________=
_____________________________________________
2.
COMPONENT INFORMATION
Component |
CAS No. |
Percent Range |
Hazardous in B=
lend |
|
|
|||
|
Toluene |
108-88-3 |
11 - 14 |
|
|
Amorphous Silica<= o:p> |
7631-86-9 |
5 - 6 |
|
This product is =
not
hazardous according OSHA 29 CFR 1910.1200.
Hazards=
:
|
Flammable/Combustible |
Yes |
Acute Toxin |
No |
Chronic Toxin |
No |
Carcinogen |
No |
|
|
|||||||||
|
Pressure |
No |
Reactive |
No |
Exposure Limit |
|
Target Organ |
|
Other |
|
|||||||||
2A. O=
THER
INGREDIENTS Greater than 3%
|
Compon=
ent |
CAS No=
. |
|
Hydrocarb= on Resin |
68132-04-= 7 |
|
Hydrated = Alumina |
21645-51-= 2 |
|
Calcium C= arbonate |
1317-65-3= |
|
Clay |
1332-58-7= |
_________________________________________________________________=
____________________
3. HAZARDS IDENTIFICATION<= o:p>
May cause moderate irritation to eyes. May be harmful if swallowed. Read and understan= d all health and safety information on the product label and Material Safety Data Sheet before use.
Health |
1 |
Flammability |
3 |
Reactivity |
0 |
Primary Route of
Exposure: Skin x Inhalation x Eye x Ingestion x
Eye
Contact: May cause eye irritation if=
wiped
or rubbed into eyes.
Skin
Contact: May=
cause mild
skin irritation on prolonged or repeated contact.
<=
/span>
Inhalation: Breath= ing high concentrations of vapors may cause nausea & irritation of nose, throat, & respiratory tract. Respiratory symptoms associated with pre-existing lung disorders may= be aggravated by exposure to this material.
&= nbsp; depression.
=
=
= &nb= sp; =
Medical Conditions Aggrava= ted by Exposure: Prolonged exposure to vapors could aggravate
= &nb= sp; = &nb= sp; = &nb= sp; pre-existing disorders in lungs, kidney and liver.
= &nb= sp; = &nb= sp; = &nb= sp;
4. FIRST AID INFORMATION
Eye Contact:= Flush with water for 15 minutes. Get medical attention immediately.=
Skin Contact: Wipe off and wash skin with soap and water. Promptly remove contaminated cloth= ing and
= = wash before reuse. Get medical attention immediately.
Inhalation: = Remove to fresh air.&= nbsp; If breathing has stopped, start artificial respiration. Oxygen may be
= administered. Consult physician immediately.
Ingestion: Do not induce vomiting unless directed to do so = by a physician. Consult a physicia= n
= immediately.
Notes to Physician:
5. FIRES AND EXPLOSION
INFORMATION
|
Flammable Limits in Air |
|
Upper Percent: 7.5% by vol |
|
|
Lower Percent: 1.0 % by vol |
|
|
Auto ignition Temperature: 222.5 deg C=
|
Test Method: NA |
NFPA Classification: H 1 F 3 R 0 =
<=
b>
<= b>Extinguishing Media: Use foam, dry chemical or carbon dioxide. Water may not be effective as an extinguishing agent. Water fo= g or spray may be used to provide a smothering effect on fire and to cool fire exposed containers and surrounding combustibles. Do not use a solid stream of water= because it can scatter and spread the fire.
Special Fire Fighting Procedures and Equipment: This product contains solvents that = are dangerous fire and explosion hazards when exposed to heat or flame. Fire fighters should wear self-con= tained breathing apparatus and full protective clothing with a full face piece operated in the positive pressure demand mode
Unusual Fire and Explosion Conditions: Extremely flammable. Store and use away= from all sources of heat, flame, or sparks.&nbs= p; Do not smoke while applying. Vapors are heavier than air and may travel along ground or may be mo= ved by ventilation and ignited by pilot lights, other flames, sparks, heaters, smoking, electrical motors, static discharge, or other ignition sources at location distant from material handling point and flash back. All containers should be grounded = when material is transferred.
&n= bsp; = ; Hazardous Combustion By-Products: Toxic gases or vapors, such as, carbon monoxide, carbon dioxide, or oxides of nitrogen may be released in a fire.
_________________________________________________________________=
_____________________
6. ACCIDENTAL RELEASE MEA=
SURES
Personnel Safeguards: Evacuate non-essential personnel to= safe areas. Clean-up responders sh= ould wear
= = &nb= sp; proper protective clothing and gloves before entering the affected area.
Regulatory Notifications: Certain component of this produc= t is defined as hazardous according to U.S.
= &nb= sp; = EPA. Spill reporti= ng requirements and reportable quantities vary by region.
= &nb= sp; = Consult all applicable state and local regulations. For Canada, observe all
=
&nb=
sp; =
precautions noted above.
Containment and Clean up: Prevent product from entering drinking water supplies or streams. Observe
= &nb= sp; = &nb= sp; above precautions, collect liquid with inert, noncombustible material and
= = &nb= sp; remove for disposal.
7. HANDLING AND STORAGE INFORMA=
TION
Handling: Keep out= of reach of children. Ground han= dling equipment. Use away from all sources of heat, flames, or sparks. Launder contaminated clothing. Wash hands with soap and water after use, especially before eating or drinking.
Storage: Store in a dry, well ventilated environment away from = heat, flame, or sparks. Keep contai= ners closed when not in use with adequate ventilation. Do not pressurize, cut weld or gri= nd containers.
&nb= sp; = Residual product and solvent vapors may ignite explosively.
Empty Container Warnings
Drums: Drums may not be reused.=
_________________________________________________________________= _____________________
8. EXPOSURE CONTROLS / PERSONAL
PROTECTION INFORMATION
|
Component |
CAS
No. |
Exposure
Limit |
|
Heptane |
142-82-5 |
400 ppm OSHA PEL/TWA 500 ppm OSHA/ STEL |
|
Toluene |
108-88-3 |
100 ppm OSHA TWA 300 ppm OSHA Ceiling |
Eye/Face Protection: Wear safety goggles or face shield. Conta= ct lenses should not be worn.
Skin Protection: Hycron®, Neoprene, or Nitrile gloves recommended.
Respiratory Protection: Provide adequate ventilatio= n to maintain vapors below PEL/TWA. If vapor
= &nb= sp; = levels are exceeded, use NIOSH approved respirator, both during = and
= &nb= sp; = immediately after application, until vapor levels are below limits. =
Ventilation:
Do not use in enclosed areas without proper explosion-proof ventilation.
=
&nb=
sp; =
&nb=
sp; =
&nb=
sp; =
&nb=
sp;
Other: Source of clean water should be available in=
the
work area for flushing eyes and skin.
Wash thoroughly with soap and water after us=
e and
before eating.
_________________________________________________________________=
_____________________
9. <=
/span> PHYSICAL AND CHEMICAL
PROPERTIES
_________________________________________________________________=
_____________________
10. STABILITY AND REACTIVITY
INFORMATION
Chemical Stabili= ty: Stable
Conditions to Av= oid: Avoid extreme heat, fire, temperature, and ignition sources.
Incompatible Materials to Avoid: Avoid strong acids, bases and strong oxidizers.
_________________________________________________________________=
_____________________
11. TOXICOLOGICAL INFORMAT=
ION
(will only print available data)
Toluene
Primary Eye Irritation: Irritating at or above 100 PEL
Primary Skin Irritation: Irritating at or above 100 PEL
Ingestion Toxicity: Causes irritati= on of gastro intestinal tract
Dermal Sensitization: Causes irritation. May be absorbed through skin.
Inhalation Toxic=
ity:
May cause irritation of the upper respiratory tract
Chronic
Exposure: May cause rever=
sible kidney
and liver injury.
Mutagenicity: NA
Carcinogenicity: NA
Reproductive Toxicity: Some evidence of reproductive effects in laboratory animals
Teratogenicity: NA
Immunotoxicity:<= /b> NA
Neurotoxicity: NA
No other toxicological information available=
__________________=
____________________________________________________________________
12. ECOLOGICAL INFORMATION=
Toluene
This material is expected to be toxic to aquatic life. The LC50/96 hour values= for fish are between 10 and 100 mg/l.
No other ecological information available
_________________________________________________________________= _____________________
Regulatory Information: Consult all regulations (federal, state, provincial, local etc.) or a qualified waste
= &nb= sp; = disposal firm when characterizing waste for disposal.
Waste Disposal Methods: Recover free liq= uid. Absorb residue and dispose of according to local, state and
= &nb= sp; = Federal EPA regulation. Empty container: may contain explosive vapor= s. Do
&nb=
sp; =
&nb=
sp; =
Not cut, puncture or weld on or nea=
rby.
_________________________________________________________________= _____________________
14. TRANSPORTATION INFORMATION
U.S. Department of Transportation (DOT)
Highway / Rail:<= /b> A red caution label is required for I gallon cans only. Adhesives, 3, UN1133, PG II
The DOT descri=
ption
is provided to assist in the proper shipping classification of this product=
and
may not be suitable for all shipping descriptions.
Other: No other information available.
___=
___________________________________________________________________________=
15. &n=
bsp;
REGULATORY INFORMATION
U.S. TSCA Inventory: All components of this mat= erial are on the US TSCA Inventory or exempt from =
= &nb= sp; = listing on the TSCA Inventory.
Sara Section 313: This product contains the fol= lowing Sara, Title III, Section 313 Chemicals:
|
Chemical= |
CAS Number |
Percent in Produ= ct |
|
Heptane |
142-82-5 |
23 - 27 |
|
Toluene |
108-88-3 |
11 - 14 |
<= /p>
<= b>IARC Group: 3
This product contains a mixture of one or more compone= nts found on the following State List at or above OSHA de minimis quantities
Environmental: NA
International: NA
State: FL, MA, MN, PA, NJ, WA, CA
National Inventories: NA
|
Acute: |
Yes |
Chronic: |
Yes |
Fire: |
Yes |
Pressure: |
No |
Reactive: |
No |
|
|
Regulated: No |
|
|
||||||||
<= b>California Proposition 65 Information: Warning! Developmental toxicity
Canadian WHMIS Classification
Heptane
This product has been classi= fied in accordance with hazard criteria of the Controlled Products
Regulations&nb= sp; (CPR). This MSDS conta= ins all the information required by the CPR.
Canadian Environmental Protection Act (CEPA)=
All reportable chemical substance is listed on the Domestic Substances List (DS= L) or otherwise complies with CEPA new substance notification requirements.
National Pollution Release Inventory (NPRI)<= o:p>
This product contains the following chemical subject to the reporting requiremen= ts of the CEPA subsection 16(1), NPRI.
|
Chemical= |
CAS Number |
Percent in Produ= ct |
|
Heptane |
142-82-5 |
23 - 27 |
|
Toluene |
108-88-3 |
11 - 14 |
Other Regulations: No other information available.
_________________________________________________________________=
_____________________
16. OTHER INFORMATION
Health and Environmental Label Language
All ingredients contained in this product are included on the US EPA Toxic Substances Control Act
<= span style=3D'mso-spacerun:yes'> (TSCA) inventory or exempt from li= sting on the TSCA inventory. All ingredients contained in this
<= span style=3D'mso-spacerun:yes'> product comply with the requiremen= ts of the Canadian Environmental Protection Act (CEPA) and are
<= span style=3D'mso-spacerun:yes'> listed on the Domestic Substance L= ist (DSL) or Non-Domestic Substance List (NDSL)
<= span style=3D'mso-spacerun:yes'>
MSDS Revisions
Previous Version Date: 06/10/04
Section
= Old Information: 16-part MSDS version
= New Information: 16-part MSDS version with updated Shipping Information
<=
b>Disclaimer
of Warranty: The information contained herein is based upon data and
information available to us, and reflects our best professional judgment.
&= nbsp; &nbs= p; &= nbsp; &nbs= p; &= nbsp; &nbs= p; &= nbsp; &nbs= p; &= nbsp; &nbs= p;